Question about 2002 Cadillac Sts
When car starts in the morning, it has power steering...then shortly after driving at 30mph...there is no power steering, car turns like a truck. Since this is variable assist steering, I wonder if some speed sensor valve is sticking and if there is anything I can do besides take it to the stealership?
Problems with electronic variable-assist systems include all of the same things that can go wrong with a conventional power steering system (leaks, center wear in the steering gears, pump & hose failures, etc.), plus problems with the control electronics including the vehicle speed sensor circuit, the solenoid valve and control module. Accurate diagnosis, therefore, is essential to minimize warranty returns. Most of these systems provide diagnostic fault codes that can be accessed with a voltmeter, test light or scan tool to pinpoint the nature of the fault (if the fault is electronic rather than mechanical or hydraulic).
If power to the solenoid or control valve actuator is lost, the valve keeps the bypass circuit closed so full power assist is provided under all driving conditions. The only indication of trouble, therefore, might be a loss of road feel and/or increased steering sensitivity at highway speeds.
It’s important to remember that variable-rate power steering only reduces the amount of pressure that reaches the steering gear at higher road speeds. The only way it could reduce power assist at low speed would be in the unlikely event the actuator or solenoid valve failed in the open position. This could cause a noticeable reduction or loss of power assist.
On GM’s Magnasteer racks, loss of current to the magnetic coils would cause a loss of power assist at low speed. Coil resistance can be checked with an ohmmeter, and should read about two ohms. An infinite (open) reading indicates a bad coil (requires replacing the rack since the coils are not serviceable). Checking for shorts between both sides of the coil assembly and rack housing is also recommended.
The system does have self-diagnostic capability, but there is only one fault code: C1241 (Magnasteer circuit malfunction). The code is set if the module detects an open or a short in the coil circuit. If this code is present, the Magnasteer system is disabled and will not vary the steering effort as vehicle speed changes. The C1241 body code can be read with a Tech 2 or equivalent scan tool. The Tech 2 tool can also be used to perform a Magnasteer function test. The test varies the current to the coil so you can check for a change in steering effort when turning the steering wheel.
Replacement racks for variable-assist power steering applications are available with or without an EVO control solenoid. As long as the original EVO control solenoid is working OK, it can be removed and installed on the replacement rack to save your customer a few bucks. There’s no need to replace the whole rack if only the EVO solenoid valve is defective.
On GM Magnasteer applications, the whole rack must be replaced if the rack or control unit is defective because the Magnasteer unit is part of the rack. Handle with care because the permanent magnets inside the Magnasteer valve assembly and connector are fragile and can be easily damaged.
Good luck and hope this helps you understand the Steering system on your STS to save you some money on what to look for and what to look out for if your going to have a auto shop repair it. Such as the Valve is replaceable and it may just be a bad wire connection.
Posted on May 22, 2009
First check it out to see if you power steering is not low and you drive belt maybe slipping if it been over 40,000 mile change the drive belt too. Michigan Man.
Posted on May 22, 2009
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
Tips for a great answer:
May 13, 2016 | Cars & Trucks
Feb 03, 2015 | Audi A5 Cars & Trucks
Oct 07, 2013 | 2001 Chevrolet Impala
Apr 09, 2013 | Honda Civic Cars & Trucks
Jan 13, 2013 | 1994 Toyota Corolla
Oct 17, 2012 | Mitsubishi Outlander Cars & Trucks
Dec 19, 2010 | 2006 Honda Accord
Jun 08, 2017 | 1994 Oldsmobile Achieva Special Edition
Jan 20, 2009 | 1998 Plymouth Breeze
1,007 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: