20 Most Recent Champion 3500/4000 Watt Portable Generator Questions & Answers


Hi, I believe the motor needs a ring job. You will have to disassemble and get new rings on the piston. Also look at valves guides they will need replacing. In short , you'll have to get a new motor.
Hope that helps.

Champion... | Answered on Dec 02, 2015


www.championpowerequipment.com/

Adjusting valves on any warm engine is wiser . Specifications are usually listed for both.

Champion... | Answered on Jun 05, 2015


Petrol or diesel?

Champion... | Answered on Nov 22, 2014


If you want it to start with a start motor, driven from a battery, my guess is the battery is in bad condition. Normally a battery will perform less when temperature is going down, but an old or worn out battery can't perform at all when it is cold. I would check that first. Just take a good battery to start one of them and see what happens. Then see if you want to replace them.

Champion... | Answered on Nov 22, 2014


Sounds like the govenor is messed up. Check the springs on the carb linkage, maybe one of the little springs has come off or broken.

Champion... | Answered on Oct 03, 2014


Carb has debris. Take float bowl off and clean and if that doesnt take care of it-clean carb completely

Champion... | Answered on Jul 26, 2014


You have a carburetor problem. Stuck float or clogged filter. Gas cannot get into the carb as fast as it is used. Letting it sit for a few minutes will allow the bowl to fill.

Champion... | Answered on Jun 08, 2014


screw anticlock wise speed regulater on the carborator

Champion... | Answered on May 10, 2014


It could be a carburetor problem or it may be the low oil cut off switch. Check to make sure oil level is up. If it is check the needle valve attached to the float and the seat. The old carbs used to have a brass seat. Some of the new carbs have a rubber seat and it may need to be replaced. Hope this helps.

Champion... | Answered on Dec 31, 2013


How did you stop it? Pull the spark plug wire?
There is a carburetor in there,somewhere.Pinch off the fuel line to or from the carb. I like needle nosed vice grips or a BIG hemostat.

Champion... | Answered on Feb 21, 2013

Not finding what you are looking for?
Champion 3500/4000 Watt Portable Generator Logo

39 questions posted

Ask a Question

Usually answered in minutes!

Top Champion Televison & Video Experts

Cindy Wells

Level 3 Expert

5965 Answers

John Ziehm
John Ziehm

Level 2 Expert

206 Answers

Joseph Hoffmann

Level 3 Expert

1755 Answers

Are you a Champion Televison and Video Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Champion Televison & Video

  • Champion Televison & Video

Most Popular Question

adj valves champion 4000 generator hot

  • Televison & Video
Loading...